Charles Daly's 1985 Pontiac Fiero
Share this article:
- Pioneer DEH-P77DH CD receiver
- Pioneer TS-A4103 4"x10" 2-way speakers dash
- Polk Audio EX351a 3-1/2" speakers head rests
- Polk Audio EX104 10" subwoofer
- Custom-built subwoofer enclosure
- Rockford Fosgate Punch 150a2 amplifier (37.5 watts RMS x 2, 140 watts in mono mode)
- Lightning Audio 1/4-farad capacitor
- StreetWires power and speaker wire
Charles began by replacing the factory receiver with the Pioneer DEH-P77DH, a GM-sized (3" tall) CD receiver with excellent power (22 watts RMS/45 peak x 4), built-in crossover and equalizer capability, and independent volume control for the subwoofer preamp outputs. Pioneer's Supertuner III provides top-notch AM/FM reception an important feature in rural Maine.
Charles installed the Pioneer TS-A4103 2-way 4"x10" speakers in the factory dash locations. With a little improvisation, Charles managed to replace the factory headrest speakers with two sets of Polk EX351a 3-1/2" speakers no easy task! All speakers were powered by the Pioneer receiver's strong internal amp (22 watts RMS/45 peak x 4). The sound was vastly improved, but still missing the powerful low frequency performance that Charles wanted. Local installers scoffed at his request for more bass, but some old-fashioned Daly ingenuity saved the day.
After much trial and error, Charles managed to design and build an enclosure to fit in the Fiero's spare tire well in the front compartment (the engine's in back). The box houses a Polk EX Series II 10" subwoofer, powered by 140 watts RMS from a Rockford Fosgate Punch 150a amplifier mounted behind the driver's seat. A tube from the sub enclosure runs through a port in the passenger side floor board (the only modification made to the vehicle), allowing bass to travel directly into the cab for increased impact. A 1/4-farad Lightning Cap ensures a constant supply of power to the Punch amp, and eases the strain on the Fiero's electrical system.
Charles reports that he receives raves on the sound of the system wherever he goes. Sports car and small car owners everywhere, take note! With a little planning and experimentation, Charles Daly's fabulous Fiero is soundin' phat!
Charles Daly with his 1985 Pontiac Fiero.
The Pioneer DEH-P77DH CD receiver sports MOSFET45 internal power and built-in crossover/equalization capability an excellent choice for getting the most out of the limited space in the Fiero.
The port on the passenger side floorboard connects directly to the custom-built subwoofer enclosure for some kickin' bass!
Charles replaced the factory headrest speakers with two pairs of Polk Audio EX351a 3-1/2" speakers it's almost like wearing headphones.
The Rockford Fosgate Punch 150a2 amplifier (with the help of a 1/4-farad Lightning Cap) punches out a healthy 140 watts RMS of bass power.
Charles designed and built this custom enclosure to house the Polk EX104 10" woofer. Every cubic inch of space in the front storage compartment is utilized!